2,2,4-트리메칠펜탄

2,2,4-트리메칠펜탄 속성

2,2,4-트리메칠펜탄 C화학적 특성, 용도, 생산

개요

Isooctane is a flammable liquid isomer of octane. It is best known for defining the octane number to rate the antiknock quality of gasoline, which is related to engine performance.
Since 1930, many chemical processes, such as alkylation and polymerization, have been developed to increase the production of branched compounds in refi nery operations. High octane numbers in gasoline are those associated with the alkenes (olefins) and aromatics, especially akyl benzene compounds. For example, 2-pentene has a RON of 154. Benzene itself has a RON of 98, but 1,3,5-trimethylbenzene has a RON of 170. The highest octane numbers in gasoline are associated with cyclic alkenes, but these account for only a minute fraction of gasoline.

화학적 성질

2,2,4-Trimethylpentane (isooctane), C8H18, is a colorless liquid naturally found in crude petroleum and in small amounts in natural gas. It is released to the environment by the petroleum industries, by automotive exhausts and emissions, and from hazardous-waste sites, landfills, and emissions from wood combustion.

물리적 성질

Octane is a colorless liquid with a gasoline-like odor. The odor threshold is 4 ppm and 48 ppm (New Jersey Fact Sheet). An odor threshold concentration of 670 ppbv was reported by Nagata and Takeuchi (1990).

용도

2,2,4-Trimethylpentane is used as a mobile phase in High Performance Liquid Chromatography and Liquid Chromatography coupled with Mass Spectrometry.

생산 방법

Isooctane is produced from the fractional distillation of petroleum fractions and naphthas. It is also produced from the alkylation of 2-methylpropene with isobutane.

정의

ChEBI: 2,2,4-Trimethylpentane is an alkane that consists of pentane bearing two methyl substituents at position 2 and a single methyl substituent at position 4.

일반 설명

A clear colorless liquid with a petroleum-like odor. Flash point 10°F. Less dense than water and insoluble in water. Vapors are heavier than air.

공기와 물의 반응

Highly flammable. Insoluble in water.

반응 프로필

Saturated aliphatic hydrocarbons, such as 2,2,4-Trimethylpentane, may be incompatible with strong oxidizing agents like nitric acid. Charring of the hydrocarbon may occur followed by ignition of unreacted hydrocarbon and other nearby combustibles. In other settings, aliphatic saturated hydrocarbons are mostly unreactive. They are not affected by aqueous solutions of acids, alkalis, most oxidizing agents, and most reducing agents.

위험도

Intermediate, azeotropic distillation entrainer.

건강위험

Inhalation or contact with material may irritate or burn skin and eyes. Fire may produce irritating, corrosive and/or toxic gases. Vapors may cause dizziness or suffocation. Runoff from fire control or dilution water may cause pollution.

화재위험

Highly flammable liquid; flash point (closed cup) －12.2°C (10°F); autoignition temperature 418°C (784°F) (NFPA 1997); fireextinguishing agent: dry chemical, foam, or CO2; use a water spray to keep fire-exposed containers cool. Isooctane forms explosive mixtures with air within the range 1–4.6% by volume of air.

Safety Profile

Mutation data reported. High concentrations can cause narcosis. A very dangerous fire hazard when exposed to heat, flame, oxidmers. Can react vigorously with reducing materials. Explosive in the form of vapor when exposed to heat or flame. To fight fire, use CO2, dry chemical. When heated to decomposition it emits acrid smoke and irritating fumes. See also ALKANES.

잠재적 노출

Octane is used as a solvent; as a fuel; as an intermediate in organic synthesis; and in azeotropicdistillations.

Carcinogenicity

Male and female rats were initiated with 170 ppm N-ethyl-N-hydroxyethylnitrosamine for 2 weeks and subsequently exposed to isooctane for 61 weeks. An increase in atypical cell foci (a preneoplastic lesion) was observed in male but not female rats promoted with the high dose.

환경귀착

Surface Water. Mackay and Wolkoff (1973) estimated an evaporation half-life of 4.1 sec from a surface water body that is 25 °C and 1 m deep.
Photolytic. The following rate constants were reported for the reaction of 2,2,4-trimethylpentane and OH radicals in the atmosphere: 2.3 x 10^-12 cm³/molecule?sec at 300 K (Hendry and Kenley, 1979); 2.83 x 10^-12 cm³/molecule?sec at 298 K (Greiner, 1970); 3.73 x 10^-12 cm³/molecule?sec at 298–305 K (Darnall et al., 1978); 3.7 x 10^-12 cm³/molecule?sec (Atkinson et al., 1979); 3.90 x 10^-12 cm³/molecule?sec at 298 K (Atkinson, 1985). Based on a photooxidation rate constant of 3.68 x 10^-12 cm³/molecule?sec for the reaction of 2,2,4-trimethylpentane and OH radicals in summer sunlight, the lifetime is 16 h (Altshuller, 1991).
Products identified from the reaction of 2,2,4-trimethylpentane with OH radicals in the presence of nitric oxide included acetone, 2-methypropanal, 4-hydroxy-4-methyl-2-pentanone, and hydroxy nitrates (Tuazon et al., 2002).
Chemical/Physical. Complete combustion in air produces carbon dioxide and water vapor. 2,2,4-Trimethylpentane will not hydrolyze in water.

운송 방법

UN1262 Octanes, Hazard Class: 3; Labels: 3-Flammable liquid.

Purification Methods

Distil isooctane from sodium, pass it through a column of silica gel or activated alumina (to remove traces of olefins), and again distilled from sodium. Extract repeatedly with conc H2SO4, then agitate it with aqueous KMnO4, wash it with water, dry (CaSO4) and distil it. Purify it also by azeotropic distillation with EtOH, which is subsequently washed out with water, and the trimethylpentane is dried and fractionally distilled. [Forziati et al. J Res Nat Bur Stand 36 126 1946.] [Beilstein 1 IV 439.]

비 호환성

Reacts with strong oxidizers, causing fire and explosion hazard. Attacks some forms of plastics, rubber and coatings.

폐기물 처리

Dissolve or mix the material with a combustible solvent and burn in a chemical incinerator equipped with an after burner and scrubber. All federal, state, and local environmental regulations must be observed.

2,2,4-트리메칠펜탄 준비 용품 및 원자재

원자재

준비 용품

2,2,4-트리메칠펜탄 공급 업체

공급자	전화	이메일	국가	제품 수	이점
BEYOND INDUSTRIES (CHINA) LIMITED	+86-21-52699951; +8613917686115	sales@beyondindustriesgroup.com	China	699	58
Shaanxi Didu New Materials Co. Ltd	+86-89586680 +86-13289823923	1026@dideu.com	China	9214	58
Henan Fengda Chemical Co., Ltd	+86-371-86557731 +86-13613820652	info@fdachem.com	China	7534	58
Henan Tianfu Chemical Co.,Ltd.	+86-0371-55170693 +86-19937530512	info@tianfuchem.com	China	21695	55
Hangzhou FandaChem Co.,Ltd.	008657128800458; +8615858145714	fandachem@gmail.com	China	9350	55
Hefei TNJ Chemical Industry Co.,Ltd.	+86-0551-65418679 +86-18949832763	info@tnjchem.com	China	2989	55
career henan chemical co	+86-0371-86658258	sales@coreychem.com	China	29914	58
Hubei Jusheng Technology Co.,Ltd.	18871490254	linda@hubeijusheng.com	CHINA	28180	58
Hebei Guanlang Biotechnology Co., Ltd.	+86-19930503282	alice@crovellbio.com	China	8822	58
Xiamen AmoyChem Co., Ltd	+86-592-6051114 +8618959220845	sales@amoychem.com	China	6387	58

2,2,4-트리메칠펜탄 관련 검색: