Chemical Safety Data Sheet MSDS / SDS
4-HYDROXYBUTYL METHACRYLATE
Revision Date:2026-03-21Revision Number:1
Product identifier
- Product name: 4-HYDROXYBUTYL METHACRYLATE
- CBnumber: CB0675383
- CAS: 29008-35-3
- Synonyms: HYDROXYBUTYL METHACRYLATE;hydroxybutyl methacrylate, mixture of isome
Relevant identified uses of the substance or mixture and uses advised against
- Relevant identified uses: For R&D use only. Not for medicinal, household or other use.
- Uses advised against: none
Company Identification
- Company: Chemicalbook
- Address: Building 1, Huihuang International, Shangdi 10th Street, Haidian District, Beijing
- Telephone: 010-86108875
GHS Label elements, including precautionary statements
-
Symbol(GHS)
- Signal wordWarning
P261 Avoid breathing dust/fume/gas/mist/vapours/spray.
P264 Wash skin thouroughly after handling.
P280 Wear protective gloves/protective clothing/eye protection/face protection.
P301+P312 IF SWALLOWED: call a POISON CENTER or doctor/physician IF you feel unwell.
Hazard statements
H317 May cause an allergic skin reaction
Substance
- Product name: 4-HYDROXYBUTYL METHACRYLATE
- Synonyms: HYDROXYBUTYL METHACRYLATE;hydroxybutyl methacrylate, mixture of isome
- CAS: 29008-35-3
- MF: C8H14O3
- MW: 158.19
General advice
Show this safety data sheet to the doctor in attendance.
If inhaled
After inhalation: fresh air.
In case of skin contact
In case of skin contact: Take off immediately all contaminated clothing. Rinse skin with water/ shower. Consult a physician.
In case of eye contact
After eye contact: rinse out with plenty of water. Call in ophthalmologist. Remove contact lenses.
If swallowed
After swallowing: immediately make victim drink water (two glasses at most). Consult a physician.
Most important symptoms and effects, both acute and delayed
The most important known symptoms and effects are described in the labelling (see section 2) and/or in section 11
Protection of first-aiders
For personal protection see section 8.
Notes to physician
No data available
Suitable extinguishing media
Foam Carbon dioxide (CO2) Dry powder
Unsuitable extinguishing media
For this substance/mixture no limitations of extinguishing agents are given.
Specific hazards during fire fighting
Combustible. Vapours are heavier than air and may spread along floors. Forms explosive mixtures with air on intense heating. Development of hazardous combustion gases or vapours possible in the event of fire.
Hazardous combustion products
Carbon oxides
Specific extinguishing methods
Prevent fire extinguishing water from contaminating surface water or the ground water system.
Special protective equipment for fire-fighters
Stay in danger area only with self-contained breathing apparatus. Prevent skin contact by keeping a safe distance or by wearing suitable protective clothing.
Personal precautions, protective equipment and emergency procedures
Advice for non-emergency personnel: Do not breathe vapours, aerosols. Avoid substance contact. Ensure adequate ventilation. Evacuate the danger area, observe emergency procedures, consult an expert. Advice for emergency responders: For personal protection see section 8.
Environmental precautions
Do not let product enter drains.
Methods and materials for containment and cleaning up
Cover drains. Collect, bind, and pump off spills. Observe possible material restrictions (see sections 7 and 10). Take up with liquid-absorbent material (e.g. Chemizorb® ). Dispose of properly. Clean up affected area.
Handling
For precautions see section 2.2.
Storage
Further information on storage conditionsTightly closed.
Storage class
10, Combustible liquids
Recommended storage temperature
2 - 8 °C
Ingredients with workplace control parameters
Contains no substances with occupational exposure limit values.
Engineering measures
No data available
Personal protective equipment
Respiratory protectionrequired when vapours/aerosols are generated.
Our recommendations on filtering respiratory protection are based on the following standards: DIN EN 143, DIN 14387 and other accompanying standards relating to the used respiratory protection system.
Recommended Filter type
Our recommendations on filtering respiratory protection are based on the following standards: DIN EN 143, DIN 14387 and other accompanying standards relating to the used respiratory protection system.
Filter type ABEK
The entrepeneur has to ensure that maintenance, cleaning and testing of respiratory protective devices are carried out according to the instructions of the producer. These measures have to be properly documented.
Eye/face protection
The entrepeneur has to ensure that maintenance, cleaning and testing of respiratory protective devices are carried out according to the instructions of the producer. These measures have to be properly documented.
Use equipment for eye protection tested and approved under appropriate government standards such as NIOSH (US) or EN 166(EU).
Safety glasses
Skin and body protection
Safety glasses
protective clothing
Hand protection
Remarks
required
Hygiene measures
Immediately change contaminated clothing. Apply preventive skin protection. Wash hands and face after working with substance.
Information on basic physicochemical properties
- Particle characteristics Particle sizeNo data available
- Molecular weight158.20 g/mol
- Oxidizing propertiesnone
- Explosive propertiesNot classified as explosive.
- Flow timeNo data available
- Viscosity, kinematicNo data available
- Viscosity, dynamicNo data available
- Decomposition temperatureNo data available
- Autoignition temperatureNo data available
- Partition coefficient: n-octanol/waterNo data available
- Water solubilityNo data available
- Density1.006 g/mL at 25 °C(lit.)
- Relative density1.006 g/mL at 25 °C(lit.)
- Relative vapor densityNo data available
- Vapor pressureNo data available
- Lower explosion limit / Lower flammability limitNo data available
- Upper explosion limit / Upper flammability limitNo data available
- Burning rateNo data available
- Flammability (liquids)No data available
- Flammability (solid, gas)No data available
- Evaporation rateNo data available
- Flash point96 °C (1,024 hPa)
Method (own results): EN 2719, Pensky-Martens closed cup - Boiling point/boiling range45 °C (33.33 hPa)
- Melting point/ rangeNo data available
- pHNo data available
- Odor ThresholdNo data available
- OdorNo data available
- ColorNo data available
- Appearanceliquid
Reactivity
Forms explosive mixtures with air on intense heating. A range from approx. 15 Kelvin below the flash point is to be rated as critical.
Chemical stability
The product is chemically stable under standard ambient conditions (room temperature) .
Possibility of hazardous reactions
Violent reactions possible with: Strong oxidizing agents
Conditions to avoid
Strong heating.
Incompatible materials
No data available
Hazardous decomposition products
In the event of fire: see section 5
11.1 Information on toxicological effects
Acute toxicityOral: No data available
Inhalation: No data available
Dermal: No data available
Skin corrosion/irritation
Inhalation: No data available
Dermal: No data available
Remarks: Causes skin irritation.
The value is given in analogy to the following substances: n-butyl methacrylate
Serious eye damage/eye irritation
The value is given in analogy to the following substances: n-butyl methacrylate
Remarks: Causes serious eye irritation.
The value is given in analogy to the following substances: n-butyl methacrylate
Respiratory or skin sensitization
The value is given in analogy to the following substances: n-butyl methacrylate
Maximisation Test - Guinea pig
Result: May cause sensitisation by skin contact.
May cause allergic skin reaction.
(OECD Test Guideline 406)
Remarks: The value is given in analogy to the following substances: n-butyl meth- acrylate
Germ cell mutagenicity
Result: May cause sensitisation by skin contact.
May cause allergic skin reaction.
(OECD Test Guideline 406)
Remarks: The value is given in analogy to the following substances: n-butyl meth- acrylate
Classified based on available data. For more details, see section 2
Carcinogenicity
Classified based on available data. For more details, see section 2
Reproductive toxicity
Classified based on available data. For more details, see section 2
Specific target organ toxicity - single exposure
Inhalation - May cause respiratory irritation.
The value is given in analogy to the following substances: n-butyl methacrylate
Specific target organ toxicity - repeated exposure
The value is given in analogy to the following substances: n-butyl methacrylate
Classified based on available data. For more details, see section 2
Aspiration hazard
Classified based on available data. For more details, see section 2
11.2 Additional Information
Classified based on available data. For more details, see section 2
Ecotoxicity
No data available
Persistence and degradability
No data available
Bioaccumulative potential
No data available
Mobility in soil
No data available
Other adverse effects
No data available
Disposal methods
Waste from residuesOffer surplus and non-recyclable solutions to a licensed disposal company.
International Regulations
IATA-DGR
UN/ID No. : Not applicable
Proper shipping name : Not applicable
Class : Not applicable
Subsidiary risk : Not applicable
Packing group : Not applicable
Labels : Not applicable
Packing instruction (cargo aircraft) : Not applicable
Packing instruction (passenger aircraft) : Not applicable
Proper shipping name : Not applicable
Class : Not applicable
Subsidiary risk : Not applicable
Packing group : Not applicable
Labels : Not applicable
Packing instruction (cargo aircraft) : Not applicable
Packing instruction (passenger aircraft) : Not applicable
IMDG-Code
UN number : Not applicable
Proper shipping name : Not applicable
Class : Not applicable
Subsidiary risk : Not applicable
Packing group : Not applicable
Labels : Not applicable
EmS Code : Not applicable
Marine pollutant : no
Proper shipping name : Not applicable
Class : Not applicable
Subsidiary risk : Not applicable
Packing group : Not applicable
Labels : Not applicable
EmS Code : Not applicable
Marine pollutant : no
Transport in bulk according to Annex II of MARPOL 73/78 and the IBC Code
Not applicable for product as supplied.
National Regulations
JT/T 617
UN number : Not applicable
Proper shipping name : Not applicable
Class : Not applicable
Subsidiary risk : Not applicable
Packing group : Not applicable
Labels : Not applicable
Environmentally hazardous : no
Proper shipping name : Not applicable
Class : Not applicable
Subsidiary risk : Not applicable
Packing group : Not applicable
Labels : Not applicable
Environmentally hazardous : no
Special precautions for user
Remarks : Not classified as dangerous in the meaning of transport regulations.
Catalogue of Hazardous Chemicals : This product is not listed in the catalogue of hazardous chemicals, but it meets the definition of hazardous chemicals and its principles of determination.
National regulatory information
Regulations on Safety Management of Hazardous Chemicals
Identification of Major Hazard Installations for Hazardous Chemicals (GB 18218)
Not listed
Hazardous Chemicals for Priority Management
Not listed under SAWS
Catalogue of Specially Controlled Hazardous
Not listed Chemicals
List of Explosive Precursors
Not listed
Regulations on Labour Protection in Workplaces where Toxic Substances are Used
Catalogue of Highly Toxic Chemicals
Not listed
Regulation of Environmental Management on the First Import of Chemicals and the Import and Export of Toxic Chemicals
China Severely Restricted Toxic Chemicals for Import and Export
Not listed
Regulation on the Administration of Precursor Chemicals
Catalogue and Classification of Precursor Chemicals
Not listed
Regulations on the Administration of Controlled Chemicals
List of Controlled Chemicals
Not listed
Regulations of Ozone Depleting Substances Management
List of Controlled Ozone Depleting Substances
Not listed
List of Controlled Ozone Depleting Substances Import and Export
Not listed
Environmental Protection Law
List of Priority Controlled Chemicals
Not listed
List of Key Controlled New Pollutants
Not listed
Full text of other abbreviations
AIIC - Australian Inventory of Industrial Chemicals
ANTT - National Agency forTransport by Land of Brazil
ASTM - American Society for the Testing of Materials
bw - Body weight
CMR - Carcinogen, Mutagen or Reproductive Toxicant
DIN -Standard of the German Institute for Standardisation
DSL - Domestic SubstancesList (Canada)
ECx - Concentration associated with x% response
ELx - Loading rate associated with x% response
EmS - Emergency Schedule
ENCS - Existing and NewChemical Substances (Japan)
ErCx - Concentration associated with x% growth rate response
ERG - Emergency Response Guide
GHS - Globally Harmonized System
GLP - Good Laboratory Practice
IARC - International Agency for Research on Can- cer
IATA - International Air Transport Association
IBC - International Code for theConstruction and Equipment of Ships carrying Dangerous Chemicals in Bulk
IC50 -Half maximal inhibitory concentration
ICAO - International Civil Aviation Organiza- tion
IECSC - Inventory of Existing Chemical Substances in China
IMDG - Interna- tional Maritime Dangerous Goods
IMO - International Maritime Organization
ISHL -Industrial Safety and Health Law (Japan)
ISO - International Organisation forStandardization
KECI - Korea Existing Chemicals Inventory
LC50 - Lethal Concen- tration to 50 % of a test population
LD50 - Lethal Dose to 50% of a test population (Median Lethal Dose)
MARPOL - International Convention for the Prevention of Pol- lution from Ships
n.o.s. - Not Otherwise Specified
Nch - Chilean Norm
NO(A)EC -No Observed (Adverse) Effect Concentration
NO(A)EL - No Observed (Adverse) Ef- fect Level
NOELR - No Observable Effect Loading Rate
NOM - Official MexicanNorm
NTP - National Toxicology Program
NZIoC - New Zealand Inventory of Chem- icals
OECD - Organization for Economic Co-operation and Development
OPPTS - Of- fice of Chemical Safety and Pollution Prevention
PBT - Persistent, Bioaccumulative and Toxic substance
PICCS - Philippines Inventory of Chemicals and Chemical Sub- stances
(Q)SAR - (Quantitative) Structure Activity Relationship
REACH - Regulation (EC) No 1907/2006 of the European Parliament and of the Council concerning theRegistration, Evaluation, Authorisation and Restriction of Chemicals
SADT - Self-Accelerating Decomposition Temperature
SDS - Safety Data Sheet
TCSI - TaiwanChemical Substance Inventory
TDG - Transportation of Dangerous Goods
TECI -Thailand Existing Chemicals Inventory
TSCA - Toxic Substances Control Act (UnitedStates)
UN - United Nations
UNRTDG - United Nations Recommendations on theTransport of Dangerous Goods
vPvB - Very Persistent and Very Bioaccumulative
WHMIS - Workplace Hazardous Materials Information System
ANTT - National Agency forTransport by Land of Brazil
ASTM - American Society for the Testing of Materials
bw - Body weight
CMR - Carcinogen, Mutagen or Reproductive Toxicant
DIN -Standard of the German Institute for Standardisation
DSL - Domestic SubstancesList (Canada)
ECx - Concentration associated with x% response
ELx - Loading rate associated with x% response
EmS - Emergency Schedule
ENCS - Existing and NewChemical Substances (Japan)
ErCx - Concentration associated with x% growth rate response
ERG - Emergency Response Guide
GHS - Globally Harmonized System
GLP - Good Laboratory Practice
IARC - International Agency for Research on Can- cer
IATA - International Air Transport Association
IBC - International Code for theConstruction and Equipment of Ships carrying Dangerous Chemicals in Bulk
IC50 -Half maximal inhibitory concentration
ICAO - International Civil Aviation Organiza- tion
IECSC - Inventory of Existing Chemical Substances in China
IMDG - Interna- tional Maritime Dangerous Goods
IMO - International Maritime Organization
ISHL -Industrial Safety and Health Law (Japan)
ISO - International Organisation forStandardization
KECI - Korea Existing Chemicals Inventory
LC50 - Lethal Concen- tration to 50 % of a test population
LD50 - Lethal Dose to 50% of a test population (Median Lethal Dose)
MARPOL - International Convention for the Prevention of Pol- lution from Ships
n.o.s. - Not Otherwise Specified
Nch - Chilean Norm
NO(A)EC -No Observed (Adverse) Effect Concentration
NO(A)EL - No Observed (Adverse) Ef- fect Level
NOELR - No Observable Effect Loading Rate
NOM - Official MexicanNorm
NTP - National Toxicology Program
NZIoC - New Zealand Inventory of Chem- icals
OECD - Organization for Economic Co-operation and Development
OPPTS - Of- fice of Chemical Safety and Pollution Prevention
PBT - Persistent, Bioaccumulative and Toxic substance
PICCS - Philippines Inventory of Chemicals and Chemical Sub- stances
(Q)SAR - (Quantitative) Structure Activity Relationship
REACH - Regulation (EC) No 1907/2006 of the European Parliament and of the Council concerning theRegistration, Evaluation, Authorisation and Restriction of Chemicals
SADT - Self-Accelerating Decomposition Temperature
SDS - Safety Data Sheet
TCSI - TaiwanChemical Substance Inventory
TDG - Transportation of Dangerous Goods
TECI -Thailand Existing Chemicals Inventory
TSCA - Toxic Substances Control Act (UnitedStates)
UN - United Nations
UNRTDG - United Nations Recommendations on theTransport of Dangerous Goods
vPvB - Very Persistent and Very Bioaccumulative
WHMIS - Workplace Hazardous Materials Information System
Disclaimer:
The information in this MSDS is only applicable to the specified product, unless otherwise specified, it is not applicable to the mixture of this product and other substances. This MSDS only provides information on the safety of the product for those who have received the appropriate professional training for the user of the product. Users of this MSDS must make independent judgments on the applicability of this SDS. The authors of this MSDS will not be held responsible for any harm caused by the use of this MSDS.