페트롤라툼
|
|
페트롤라툼 속성
- 녹는점
- 70-80 °C ((ASTM D 127))
- 끓는 점
- 322 °C
- 밀도
- 0.84
- 굴절률
- n
20/D 1.45
- 인화점
- 198 °C
- 저장 조건
- Sealed in dry,Room Temperature
- 용해도
- Practically insoluble in acetone, ethanol, hot or cold ethanol (95%), glycerin, and water; soluble in benzene, carbon disulfide, chloroform, ether, hexane, and most fixed and volatile oils.
- 물리적 상태
- 초저점도 오일
- 색상
- 하얀색
- Specific Gravity
- 0.815~0.880 (60℃)
- 수소이온지수(pH)
- pH (25℃) : 4.5~8.0
- 냄새
- 냄새 없는
- 수용성
- 물에 불용성
- Dielectric constant
- 2.0(Ambient)
- 안정성
- 안정적인. 타기 쉬운. 강한 산화제와 호환되지 않습니다.
안전
- 위험 및 안전 성명
- 위험 및 사전주의 사항 (GHS)
위험품 표기 | T | ||
---|---|---|---|
위험 카페고리 넘버 | 45 | ||
안전지침서 | 24/25-45-53 | ||
WGK 독일 | 3 | ||
RTECS 번호 | RV0350000 | ||
HS 번호 | 27121000 | ||
유해 물질 데이터 | 8009-03-8(Hazardous Substances Data) | ||
기존화학 물질 | KE-28170 |
페트롤라툼 C화학적 특성, 용도, 생산
용도
의약,화장품원료,모형용점토.화학적 성질
Petrolatum is a pale yellow to yellow-colored, translucent, soft unctuous mass. It is odorless, tasteless, and not more than slightly fluorescent by daylight, even when melted.용도
petrolatum (petroleum jelly; Vaseline) softens and smoothes the skin. It forms a film on the skin’s surface, preventing moisture loss caused by evaporation, and protecting against irritation. Its disadvantage lies in the difficulty of effectively and properly removing it from the skin. Studies indicate that petrolatum accelerates the recovery of skin surface lipids, permeating throughout the stratum corneum layer, and allowing normal barrier recovery despite its occlusive properties. Thus it does not form or act as an impermeable membrane. It is a purified mixture of semisolid hydrocarbons from petroleum. Petrolatum imparts a greasier feeling than other emollients and also has the potential for clogging pores and causing comedogenicity. Although it can cause allergic skin rashes, petrolatum is non-toxic to the skin when properly purified and of high grade.생산 방법
Petrolatum is manufactured from the semisolid residue that remains after the steam or vacuum distillation of petroleum.This residue is dewaxed and/or blended with stock from other sources, along with lighter fractions, to give a product with the desired consistency. Final purification is performed by a combination of high-pressure hydrogenation or sulfuric acid treatment followed by filtration through adsorbents. A suitable antioxidant may be added.일반 설명
Dark brown, green, amber or white odorless thick liquid. Floats on water.반응 프로필
Petrolatum is unreactive in most circumstances.건강위험
LIQUID: Irritating to eyes.화재위험
Combustible.Pharmaceutical Applications
Petrolatum is mainly used in topical pharmaceutical formulations as an emollient-ointment base; it is poorly absorbed by the skin. Petrolatum is also used in creams and transdermal formulations and as an ingredient in lubricant formulations for medicated confectionery together with mineral oil.Therapeutically, sterile gauze dressings containing petrolatum may be used for nonadherent wound dressings or as a packing material.Petrolatum is additionally widely used in cosmetics and in some food applications.
Safety Profile
When heated to decomposition it emits acrid smoke and irritating fumesSafety
Petrolatum is mainly used in topical pharmaceutical formulations and is generally considered to be a nonirritant and nontoxic material.Animal studies, in mice, have shown petrolatum to be nontoxic and noncarcinogenic following administration of a single subcutaneous 100 mg dose. Similarly, no adverse effects were observed in a 2-year feeding study with rats fed a diet containing 5% of petrolatum blends.
Although petrolatum is generally nonirritant in humans following topical application, rare instances of allergic hypersensitivity reactions have been reported,as have cases of acne, in susceptible individuals following repeated use on facial skin. However, given the widespread use of petrolatum in topical products, there are few reports of irritant reactions. The allergic components of petrolatum appear to be polycyclic aromatic hydrocarbons present as impurities. The quantities of these materials found in petrolatum vary depending upon the source and degree of refining. Hypersensitivity appears to occur less with white petrolatum and it is therefore the preferred material for use in cosmetics and pharmaceuticals.
Petrolatum has also been tentatively implicated in the formation of spherulosis of the upper respiratory tract following use of a petrolatum-based ointment packing after surgery,and lipoid pneumonia following excessive use in the perinasal area.Other adverse reactions to petrolatum include granulomas (paraffinomas) following injection into soft tissue.Also, when taken orally, petrolatum acts as a mild laxative and may inhibit the absorption of lipids and lipid-soluble nutrients.
Petrolatum is widely used in direct and indirect food applications. In the USA, the daily dietary exposure to petrolatum is estimated to be 0.404 mg/kg body-weight.
For further information see Mineral Oil and Paraffin.
저장
Petrolatum is an inherently stable material owing to the unreactive nature of its hydrocarbon components; most stability problems occur because of the presence of small quantities of impurities. On exposure to light, these impurities may be oxidized to discolor the petrolatum and produce an undesirable odor. The extent of the oxidation varies depending upon the source of the petrolatum and the degree of refinement. Oxidation may be inhibited by the inclusion of a suitable antioxidant such as butylated hydroxyanisole, butylated hydroxytoluene, or alpha tocopherol.Petrolatum should not be heated for extended periods above the temperature necessary to achieve complete fluidity (approximately 70°C).
Petrolatum may be sterilized by dry heat. Although petrolatum may also be sterilized by gamma irradiation, this process affects the physical properties of the petrolatum such as swelling, discoloration, odor, and rheological behavior.
Petrolatum should be stored in a well-closed container, protected from light, in a cool, dry place.
비 호환성
Petrolatum is an inert material with few incompatibilities.Regulatory Status
GRAS listed. Accepted for use in certain food applications in many countries worldwide. Included in the FDA Inactive Ingredients Database (ophthalmic preparations; oral capsules and tablets; otic, topical, and transdermal preparations). Included in nonparenteral medicines licensed in the UK. Included in the Canadian List of Acceptable Non-medicinal Ingredients.페트롤라툼 준비 용품 및 원자재
원자재
준비 용품
페트롤라툼 공급 업체
글로벌( 363)공급 업체
공급자 | 전화 | 이메일 | 국가 | 제품 수 | 이점 |
---|---|---|---|---|---|
Hebei Yanxi Chemical Co., Ltd. | +8617531190177 |
peter@yan-xi.com | China | 5873 | 58 |
Hangzhou ICH Biofarm Co., Ltd | +86-0571-28186870; +undefined8613073685410 |
sales@ichemie.com | China | 990 | 58 |
Hebei Zhuanglai Chemical Trading Co.,Ltd | +8613343047651 |
admin@zlchemi.com | China | 2998 | 58 |
Hebei Mojin Biotechnology Co.,Ltd | +86-15028179902 |
angelia@hbmojin.com | China | 1069 | 58 |
Henan Tianfu Chemical Co.,Ltd. | +86-0371-55170693 +86-19937530512 |
info@tianfuchem.com | China | 21667 | 55 |
Hefei TNJ Chemical Industry Co.,Ltd. | +86-0551-65418679 +8618949832763 |
info@tnjchem.com | China | 2989 | 55 |
Shanghai Zheyan Biotech Co., Ltd. | 18017610038 |
zheyansh@163.com | CHINA | 3620 | 58 |
Hubei Jusheng Technology Co.,Ltd. | 18871490254 |
linda@hubeijusheng.com | CHINA | 28180 | 58 |
Hebei Guanlang Biotechnology Co., Ltd. | +86-19930503282 |
alice@crovellbio.com | China | 8820 | 58 |
Xiamen AmoyChem Co., Ltd | +86-592-6051114 +8618959220845 |
sales@amoychem.com | China | 6387 | 58 |